“At the collar machine, at which I was stationed after lunch, there was an adequate guard where the collars were slipped in.  Where they came out, however, they had to be pushed in rapid succession under the farther side of a burning hot cylinder with no guard at all.  To avoid touching the cylinder with my arm in this process, I was obliged either to raise it unnaturally high, or to stand on tiptoe.  ’You didn’t get burned to-day or yesterday,’ said Jenny, ’but you sure will sometime.  Everybody does on that machine.’

“In the ironing of collars and cuffs by machinery, there is continual risk of burns on hands and arms.  At a sleeve-ironing machine, in another place I received some slight burn every day.  And when I asked the girls if this were because I was ‘green,’ they replied that every one got burned at that machine all the time.  Each burn is due to ‘carelessness,’ but if the girls were to be careful, they would have to focus their minds on self-protection instead of the proper accomplishment of their task, and would also have to work at a lower rate of speed than the usual output of the laundries demands.  A graver danger than that from hot surfaces and from slightly protected gas flames is from unguarded belts and gears.

“At mangles, too, the danger is grave.  What the girls call ’millionaire work’—­work that has to come out straight—­in contrast with ’boarding-house work,” must be shoved up to within a quarter of an inch of the cylinder.  Fingers once caught in such mangles are crushed.  Consider, in connection with these two facts, the high rate of speed at which the girls feed the work into the machine, and the precarious character of their task will be realized.  However, in many laundries, good mangles for table and bed linen are in use, which either have a stationary bar in front of the first cylinder, or else have the first roll, whether connected or not with the power, attached to a lever, and so constructed as to lift the pressure immediately from the finger, should it be slipped underneath.[34]

“For the purpose of inspecting the machinery I visited with different factory inspectors, through the courtesy extended by the Department of Labor, all, so far as I was able to determine, of the commercial steam laundries in the borough of Manhattan.  Out of sixty laundries inspected, I found that twenty-six had either unguarded or inadequately guarded mangles, collar presses, and collar dampeners, or else unguarded or inadequately guarded gears and belts.  In a laundry visited when the boss was out, we conferred with the engineer about one particularly bad mangle.

“‘What’s this machine for?  To cut girls’ hands off?’ asked the inspector.

“‘Well,’, said the engineer, ’it came pretty near finishing up the last girl we had here—­caught her arm in an apron-string and got both hands under the roll—­happened over two months ago.  Fingers cut off one hand, and all twisted and useless on the other.’